FAQ: How To Repair Royalex Canoe?

Why is Royalex discontinued?

Royalex was extremely tough but if hit hard enough could be dented. In 2013, plastics company PolyOne, of Avon Lake, Ohio purchased Spartech, and decided to shut down Royalex production due to its low volume. The last sheets of Royalex were shipped from the factory in December, 2013.

How long will a Royalex canoe last?

So, how long should a canoe last? A Canoe will usually last for about 10-15 years before it needs major repairs or to be replaced. If you store your canoe properly and fix problems as they arise due to regular wear and tear, your canoe can last throughout your child’s childhood and even into adulthood.

How do you maintain a Royalex canoe?

A UV-resistant spray like 303 Protectant will make your canoe shine. Spray it on at least once per season to shield the hull from fading due to sunlight exposure, and to hide scratches and keep it more supple.

Will epoxy stick to Royalex?

A 2-part epoxy putty to fill in gouges and cuts that do not go through the boat. BREAKS/CUTS/PUNCTURES: Polyethylene/Royalex repair kit (part #1331.0641). Though this kit was originally developed for repairing Discovery canoes, it works equally well on our Royalex hulls.

You might be interested:  Often asked: How To Fish Lake Carlos Mn From A Canoe?

Are Royalex canoes any good?

Royalex canoes are also extremely durable and very popular with paddlers looking for a lighter alternative to polyethylene that won’t break the bank. So if you are looking for a durable canoe that is lighter and more affordable than the more expensive Kevlar and Carbon canoes, Royalex is a great option.

Which is lighter aluminum or fiberglass canoe?

Aluminum canoes are lighter than wood but heavier than fiberglass. The overall benefit of aluminum canoes is durability. They’re slow moving but tough and require very little maintenance.

How much should I pay for a used canoe?

On average, a used canoe will cost about $400 but can range anywhere from $300 to $550 dollars. A brand new canoe will, on average, cost $900.

Which canoe material is best?

Royalex. For years Royalex has been the go-to material for most casual canoe buyers. Lighter than polyethylene and with more variety of design than aluminum, Royalex is essentially a plastic sandwich made of layers of vinyl, plastic and rigid foam.

How do you know if a canoe is Royalex?

When examining a Royalex canoe, look for creases or wrinkles running up and down the hull, which can indicate if it has been wrapped and then punched out. If there are new-looking skid plates, take a look at the boat from the inside to determine if they may be hiding damage.

How do you get scratches out of a canoe?

Use a heat gun on low heat or a blow dryer on high heat running over the gel-filled scratches until they disappear. Take extra precaution to not melt or cause any extra damage to your kayak. Allow gel to cure and bond for at least 24 hours before the next use.

You might be interested:  FAQ: How Deep Sand Fibreglass Wood Canoe?

Can you wax a Royalex canoe?

To beautify, we suggest a vinyl protectant product such as Armor All®, 303 Products or Pledge. These are safe for use on any of our Polyethylene, Superlinear, Royalex® and Fiberglass canoes or kayaks. We do not recommend waxing your hull with a paste wax, such as most car waxes.

Can you patch a Royalex canoe?

CAN IT BE REPAIRED? Unless it’s big the hole can be fixed pretty easily by taping a piece of cardboard with a piece of wax paper or plastic wrap on the outside of the hull and then building up the gap with layers of fiberglass cloth and Royalex® resin.

How do you clean a Royalex canoe?

1) Clean hull with soap and water thoroughly and wipe dry. 2) Position hull so that accidental contact with gunwales or other components will be minimized and have clean dry rag at hand to wipe up any contacted areas. 3) Apply Xylene to clean rag and wipe down hull starting at one end and working towards the other.

How much is my canoe worth?

Any wooden or wood/canvas canoe in usable condition is worth $1000 – $1500. A canoe that is documentable will go on the high end, one that is particularly rare will bring more, up to $3000 for a wood canvas canoe, and as high as $5000 for an all-wood canoe.

Leave a Reply

Your email address will not be published. Required fields are marked *